Pengolahan air limbah industri penyamakan kulit menggunakan abu terbang bagas secara batch

Muhammad Sholeh, Agus Prasetya, Sarto Sarto

Abstract


The objective of this research was to evaluate the adsorption ability of chemically activated bagasse fly ash using H O or H SO to remove COD from tannery wastewater and to obtain 2 adsorption isotherm model in batch system. Two stages have been carried out, namely the activation experiment and the adsorption isotherm experiment. In the activation experiment, effect of H O dan H SO (3% and 7,5% w/w) were studied. The best result of the variation was used in the next experiment. In the adsorption isotherm experiment, variation of the initial concentrations of COD from 52,53 to 1665,79 mg/L and mass of bagasse fly ash from 0,1 to 0,4 g were used. Equilibrium data was used to evaluate the parameters in the Langmuir, Freundlich, and Temkin equations. The best model was evaluated using determination coefficients. The results showed that bagas fly ash had better ability to reduce the COD when it was not activated with H O nor H SO (3% and 7,5%). Freundlich model was best to describe COD removal using bagasse fly ash in batch system. Freundlich equation constants K and n were F 0,4360 (mg/g)/(L/mg)1/n and 1,2969 respectively and the determination coefficient obtained was 0,93.

  

Keywords: Chemical Oxygen Demand, tannery wastewater, bagasse fly ash, adsorption


Full Text:

PDF

References


Akhtar, M., Hasany, S. M., Bhanger, M. I., dan Iqbal, S. (2007). Low Cost Sorbents for the Removal of Methyl Parathion Pesticide from Aqueous Solutions. Chemosphere, 66, 1829-1838

Aksu, Z., & Gonen, F. (2004). Biosorption of Phenol by Immobilized Activated Sludge in a Continous Packed Bed: Prediction of Breakthrough Curve. Process Biochemistry, 39, 599-613

Amuda, O. S., & Ibrahim, A. O. (2006). Industrial Wastewater Treatment Using Natural Material as Adsorbent. African Journal Biotechnology, 5, 1483-1487

ASTM Commitee on Standards.(1999). ASTM D4607: Standard Test Method for Determination of Iodine Number of Activated Carbon.

Choma, J., Burakiewcz-Mortzka, W.,Jaroniec, M., Li, Z., & Klinik, J. (1999). Monitoring Changes in Surface and Structural Properties of Porous Carbons Modifird by Different Oxidizing Agents, J. Colloid Interface Sci., 214, 438-446

Do, D. D. (1998). Adsorption Analysis: Equilibria and Kinetics, Series on Chemical Engineering, 2, 13-16

El-Hendawy, A. N. (2003). Influence of HNO3 Oxidation on the Structure and Adsorptive Properties of Corncob-Based Activated Carbon. Carbon, 41, 713-722

Furniss, B.S., Hannaford, A.J., Smith, P.W.,&Tatchel, A.R.(1989).Vogel’s Textbook of Practical Organic Chemistry

Gupta, V.K., &Ali,I.(2001).Removal of DDD and DDE from Wastewater Using Baggase Fly Ash, A Sugar Industry Waste, Wat.Res, 35, 33-40

Gupta, V.K., & Sharma, S.(2003).Removal of Zink from Aqueous Solution Using Bagasse Fly Ash-Low Cost Adsorbent.India Engineering Chemical R, 42,6619-6624

Propinsi DIY.(1998).KepGub Nomor 281/KPTS/1998:Baku Mutu Limbah Cair Bagi Kegiatan Industri di Provinsi DIY, Indonesia

Lataye,D.H., Mishra,I.M.,&Mall, I.D.(2006).Removal of Pyridine from Aqueous Solution by Adsorption on Bagasse Fly Ash. India Engineering Chemical R,45,3934-3943

Mall, I.D., Srivastava, V.C., Agarwal,N.K.,&Mishra, I.M.(2005).Adsorptive Removal of Malatichit Green Dye from Aqueous Solution by Bagasse Fly Ash and Activated Carbon Kinetics Study and Equilibrium Isoterm Analysis. Colloid Surface,264,17-28

Mall, I.D., Srivastava, V.C., & Agarwal,N.K.(2005).Adsorptive Removal of Auramine-O:Kinetic and Equilibrium Study. J.Hazard.Material.DOI:10.1106/jhazmat.2006.09.059

Rachakornkij,M., Ruangchuay,S.,&Teachakulwiroj,S.(2004).Removal of Reaktif Dyes from Aqueous Solution Using Bagassa Fly Ash.Songklanakarin J.Sci.Technol,26,13-24

BSN (Badan Standardisasi Nasional).(2009).SNI (Standar Nasional Indonesia) 6989.73:2009: Air dan Air LimbahBagian 73: Cara Uji Kebutuhan Oksigen Kimiawi (Chemical Oxigen Demand/COD) dengan Refluks tertutup secara titrimetri.Jakarta.Indonesia:BSN

Srivastava, V.C., Mall, I.D.,&Mishra,I.M.(2007).Multicomponent Adsorption Study of Metal Ions onto Bagasse Fly Ash using Taguchi’s Design of Experimental Methodology. Ind. Eng. Chem. Res, 46, 5697-5706

Sudiyo,R., Sumardi,P.C.,&Prasetya, A.(2006).Recovery of Silica from Bagasse Ashes of Sugar-cane Industry in Yogyakarta, Proceeding Final Report Hi Link Project Researc

Taha,G.M.(2006).Utilization of Low Cost Waste Mterial Bagasse Fly Ash in Removing of Cu2+, Ni2+, Zn2+, and Cr3+ from Industrial Wastewater.Ground Water Monitoring and Remediation,26,137-141




DOI: http://dx.doi.org/10.20543/mkkp.v28i1.202

Refbacks

  • There are currently no refbacks.


Copyright (c) 2012 Muhammad Sholeh

Creative Commons License
This work is licensed under a Creative Commons Attribution 4.0 International License.

 

MKKP indexed by:

Cover Page Cover Page     Cover Page    Cover Page     Cover Page     Cover Page     Cover Page     Cover Page     Cover Page     Cover Page    Cover Page    Cover Page    Cover Page     Cover Page     Cover Page   Cover Page   Cover Page   Cover Page   Cover Page              

 

 

 

Free counters!